Mercedes-Benz Parts Catalog Mercedes-Benz Accessories Catalog Mercedes-Benz Technical Articles Mercedes-Benz Tech Forums
 
Follow Pelican Parts on Facebook Follow Pelican Parts on Twitter Follow Pelican Parts on Instagram Follow Pelican Parts on YouTube Follow Pelican Parts on Pinterest Follow Pelican Parts on Tumblr
  Search our site:    
View Recent Cars  |   Cart  | Project List | Order Status | Help    
 >  >
Differential Fluid Replacement
 
Bookmark and Share

Pelican Technical Article:

Differential Fluid Replacement

Steve Vernon

Time:

1 hour1 hr

Tab:

$35

Talent:

*

Tools:

14mm Allen, extension, fluid pump

Applicable Models:

Mercedes-Benz C350 (2008-14)
Mercedes-Benz GLK350 (2010-14)

Parts Required:

Differential Fluid

Hot Tip:

Clean around the differential before you start

Performance Gain:

Smoother drive train operation

Complementary Modification:

Check your CV joints

A differential is just like any other mechanism with moving parts. It generates heat and friction while in operation. Just like in an engine or transmission, regular oil changes help to keep the bearings and gears inside well lubricated and clean. Over time, the differential wears just like any other component. However, it has no internal filter to capture small particles of metal as the gears wear. Usually, differential oil is good for up to 80,000 miles without changing, however it is commonly overlooked. Failure to change the fluid at regular intervals can eventually cause the bearings in the differential to fail.

Get the oil in the differential warm before you drain it, it will help get the impurities out.

Next safely jack up and support your vehicle. You will need to jack up both ends of the vehicle as the fluid level needs to be set with the vehicle level. Please see our article on safely jacking up and supporting your W204. If your differential is dirty clean around the plugs so no dirt or debris will get into the diff while you are working.

There are two plugs on the differential.
Figure 1

There are two plugs on the differential. The fill plug (yellow arrow) is on the left side of the diff higher than the drain plug. The drain plug is on the lower right side (red arrow).

As with any fluid change always make sure you can remove the fill plug BEFORE the drain plug.
Figure 2

As with any fluid change always make sure you can remove the fill plug BEFORE the drain plug. If you drain the fluid and then cannot get the fill plug out you will have no way to drive to a store and get anything to help you remove the fill plug. Use a 14mm Allen and an extension so you can get around the exhaust and remove the fill plug (red arrow). These plugs can get set pretty tight in the diff over the years so make sure the Allen is properly seated.

Place a collection pan or bucket under the differential and remove the 14mm Allen Plug (red arrow).
Figure 3

Place a collection pan or bucket under the differential and remove the 14mm Allen Plug (red arrow). Let the differential drain completely then reinstall the drain plug.

Check the drain plug so any dirt, debris or metal shavings (red arrow).
Figure 4

Check the drain plug so any dirt, debris or metal shavings (red arrow). Small metal shavings are normal but any large bits or pieces are a sign of serious trouble.

Due to the location of the fill hole you will need to use a fluid pump to get the fluid into the differential (red arrow).
Figure 5

Due to the location of the fill hole you will need to use a fluid pump to get the fluid into the differential (red arrow).

Fill the differential until the fluid starts draining out of the fill hole (red arrow).
Figure 6

Fill the differential until the fluid starts draining out of the fill hole (red arrow). Reinsert the fill plug and torque to spec.

Bookmark and Share
Comments and Suggestions:
V Comments: What type of differential fluid should I use for 2012 Mercedes C300? 75W/140 for limited slip?
August 25, 2016
  Followup from the Pelican Staff: I found all fluids here:

http://www.pelicanparts.com/cgi-bin/ksearch/PEL_search_2014.cgi ?SUPERCAT_FLAG=Y&make=MBZ&command=DWsearch&please_wait=N&SECTION_FILTER=basmis&description=gear%20oil%20

To be sure you pick the right one, Give our parts specialists a call at 1-310-626-8765
- Nick at Pelican Parts
 
Chisel Comments: On a W202, how much diff fluid is required for a refill?
April 19, 2016
  Followup from the Pelican Staff: I would have 1.5 quarts on hand in case you spill any. - Nick at Pelican Parts  

  Search our site:    

View Cart & CheckOut | Project List | Order Status |  Help    

 

[Home] [Customer Service] [Shopping Cart] [Project/Wish List]
  [Privacy Statement]  [Contact Us] [About Us] [Shipping] [Careers]

Copyright © Pelican Parts Inc. -    DMCA Registered Agent Contact Page

Page last updated: Fri 12/9/2016 02:58:50 AM